Mercedes sprinter 308CDI / 2001 / 110.000km Conversion "finished" 10/2019. All new components. Full paint job with Raptor Liner.
|Number of cylinders||4|
|Horsepower||82pk > possible tuning to145pk (so far not needed, even 20% uphill mountain roads Slovenia and Alps)|
Sprintshift automatic gearbox, 110.000km, full maintenance (oil gearbox - diff - brake fluid - belts - battery - glow plugs...)|
Engine Diesel preheater Eberspächer > preheat engine coolant or as extra boost for heating in cab when engine is running.
Remote control alarm with 3 motion sensors and 3horns > each in every compartment and will switch on together when 1 is triggered for 5min (adjustable)
Hidden switch to disconnect start relais AND gearbox computer.
Alarm horn outside that can be switched on when lying in bed if needed.
|4x2, 4x4, 6x6, 8x8||4x2|
|Number of seats||2|
|Type of tyre||all season Pirelli Carrier M/S|
|Tank capacity||70lt + 20lt canister in garage.|
3 piece leaf spring instead of the original 1piece, all new brake pads and power discs in front.|
Full lenght vehicle = 6mt / H 3.0mt /B 2mt
|Manufacturer of the cabin||Kögel|
|Inner dimensions (LxWxH)||3300x185x1850|
|Outer dimensions (LxWxH)||3500x2000x2000|
|Cabin material||Outside polyester - side walls inside Dibond.|
|Kind and thickness of insulation||Roof 7cm / back wall (and underneath bed) 6cm / floor 2cm x-trem+2cm plywood / walls 3cm|
|Number of beds||2 > each with good quality foam matras (12 and 18cm) and slatted base for ventilation. (1850 x 800)|
|Windows||2 sliding windows in back, sliding window in door (extra air and window for dogs ;) roof hatch Righo (500x500)|
Garage area serves as "dryer room" with extra outlet from diesel heater (open/close when needed) permanent ventilation and forced with fan when needed.|
Led lights living area, outside and garage.
3-gas detector and extra fire extinguisher in living area, smoke detector in garage.
Bluetooth DAB+ radio with new speakers in dachboard and extra sub woofer under seat. (JBL)
Refrigerator; cool box
|Manufacturer and type of fridge / cooler||Dometic rm5310 absorption with extra fan automatic controlled by temp switch|
|3 way (gas / 12V / 220V)|
|Voltage in the chassis||12V|
|Voltage in the cabin||12V|
|Charging converter 24V-12V||Split charge relais with switch if motor battery would be defect.|
|110V / 230V in the cabin?||yes|
Victron cyrix / Waeco shore power switch|
Seperet power outlets in kitchen from shore power or inverter.
Light and 220 v outlet top bed.
Capacity of batteries in the cabin
|Capacity of batteries in the cabin||230Ah (5/2019)|
|Battery charger for cabin batteries||Victron bleu smart 30A|
|Explanation of gas system|
|15kg bottle(s) to main collector in kitchen unit to switch off stove, fridge and boiler separately.|
|water flow||Shurflo trial king 2.8bar|
|Water filtration system||Shurflo|
|Capacity of fresh water tank(s)||100lt > filling with hose on top|
|Capacity of waste water tank(s)||50lt|
|Extra 20lt canister in garage to fill the tank when there is no tap if or just extra capacity.|
|Awning||Omnistor 5001 (3.5mt)|
owner Ben Verheyen
filled out 96%